No glows plugs on a vw passat from cold

check it the heater control is allowing hot water through the heater core.(turning the tap on )

In addition to the 4 primary glow plugs, the cooling system also has 3 Coolant Glow Plugs to help provide extra heat to the cooling system in order to warm-up the vehicle's interior more quickly, and enhance overall engine warm-up time. (Example - Some Mercedes diesel engines use electrical heaters in the cabin because their engine is so thermally efficient.)
Likewise, this auxiliary source of heat from the 3 Coolant Glow Plugs is necessary because of the VW 1.9 TDI engines outstanding efficiency, which wastes very little heat.

The 3 Auxiliary Coolant Glow Plugs are located at the end of the aluminum cylinder head (in a protruding flange) directly below the vacuum (brake booster) pump, which also connects to a coolant hose.


The 3 Auxiliary Coolant Glow Plugs use two (underhood) relays which are monitored and controlled by the ECU. During a cold start, the vehicle's interior temperature selector switch helps the ECU choose one of three modes depending on the amount of heat required to warm-up the coolant.

For example, Coolant Glow Plug #1 can be selected to operate all by itself, or #2 and #3 can operate together as a two-some, or lastly, all three glow plugs can form a triple source of heat for maximum enhancement of engine warm-up time.

After the engine is completely warmed up and the thermostat is open, the Coolant Glow Plugs normally shut-off and remain off unless the (thermally efficent) engine cools down sufficiently to have the computer signal them to come back on to keep the engine and cabin air warm. Extensive idling times at stop lights or in the driveway are scenarios where these glow plugs are most likely to recycle on and off.

In conclusion, the period of Preglow and Afterglow is determined by the engine's coolant temperature (during a cold or hot start), which helps the ECU select a predetermined time-cycle for the combustion chamber and / or Auxiliary Coolant Glow Plugs to follow.

Finally, one myth that needs to be immediately debunked, is the belief that the TDI's advanced Glow Plug System is linked to the opening of the driver's side door, which is false! It is also noteworthy to mention that some earlier VW diesel glow plug systems were operated in this manner, but not so with the advanced VW Jetta 1.9 TDI engine.

In addition to the 4 primary glow plugs, the cooling system also has 3 Coolant Glow Plugs to help provide extra heat to the cooling system in order to warm-up the vehicle's interior more quickly, and enhance overall engine warm-up time. (Example - Some Mercedes diesel engines use electrical heaters in the cabin because their engine is so thermally efficient.)
Likewise, this auxiliary source of heat from the 3 Coolant Glow Plugs is necessary because of the VW 1.9 TDI engines outstanding efficiency, which wastes very little heat.

The 3 Auxiliary Coolant Glow Plugs are located at the end of the aluminum cylinder head (in a protruding flange) directly below the vacuum (brake booster) pump, which also connects to a coolant hose.



The 3 Auxiliary Coolant Glow Plugs use two (underhood) relays which are monitored and controlled by the ECU. During a cold start, the vehicle's interior temperature selector switch helps the ECU choose one of three modes depending on the amount of heat required to warm-up the coolant.

For example, Coolant Glow Plug #1 can be selected to operate all by itself, or #2 and #3 can operate together as a two-some, or lastly, all three glow plugs can form a triple source of heat for maximum enhancement of engine warm-up time.

After the engine is completely warmed up and the thermostat is open, the Coolant Glow Plugs normally shut-off and remain off unless the (thermally efficent) engine cools down sufficiently to have the computer signal them to come back on to keep the engine and cabin air warm. Extensive idling times at stop lights or in the driveway are scenarios where these glow plugs are most likely to recycle on and off.

In conclusion, the period of Preglow and Afterglow is determined by the engine's coolant temperature (during a cold or hot start), which helps the ECU select a predetermined time-cycle for the combustion chamber and / or Auxiliary Coolant Glow Plugs to follow.

Finally, one myth that needs to be immediately debunked, is the belief that the TDI's advanced Glow Plug System is linked to the opening of the driver's side door, which is false! It is also noteworthy to mention that some earlier VW diesel glow plug systems were operated in this manner, but not so with the advanced VW Jetta 1.9 TDI engine.



Please do rate my response. Thanks!

In addition to the 4 primary glow plugs, the cooling system also has 3 Coolant Glow Plugs to help provide extra heat to the cooling system in order to warm-up the vehicle's interior more quickly, and enhance overall engine warm-up time. (Example - Some Mercedes diesel engines use electrical heaters in the cabin because their engine is so thermally efficient.)
Likewise, this auxiliary source of heat from the 3 Coolant Glow Plugs is necessary because of the VW 1.9 TDI engines outstanding efficiency, which wastes very little heat.

The 3 Auxiliary Coolant Glow Plugs are located at the end of the aluminum cylinder head (in a protruding flange) directly below the vacuum (brake booster) pump, which also connects to a coolant hose.


The 3 Auxiliary Coolant Glow Plugs use two (underhood) relays which are monitored and controlled by the ECU. During a cold start, the vehicle's interior temperature selector switch helps the ECU choose one of three modes depending on the amount of heat required to warm-up the coolant.

For example, Coolant Glow Plug #1 can be selected to operate all by itself, or #2 and #3 can operate together as a two-some, or lastly, all three glow plugs can form a triple source of heat for maximum enhancement of engine warm-up time.

After the engine is completely warmed up and the thermostat is open, the Coolant Glow Plugs normally shut-off and remain off unless the (thermally efficent) engine cools down sufficiently to have the computer signal them to come back on to keep the engine and cabin air warm. Extensive idling times at stop lights or in the driveway are scenarios where these glow plugs are most likely to recycle on and off.

In conclusion, the period of Preglow and Afterglow is determined by the engine's coolant temperature (during a cold or hot start), which helps the ECU select a predetermined time-cycle for the combustion chamber and / or Auxiliary Coolant Glow Plugs to follow.

Finally, one myth that needs to be immediately debunked, is the belief that the TDI's advanced Glow Plug System is linked to the opening of the driver's side door, which is false! It is also noteworthy to mention that some earlier VW diesel glow plug systems were operated in this manner, but not so with the advanced VW Jetta 1.9 TDI engine.

Your glow plugs should warm your engine enough to start ... you do have glow plugs, right?

You might want to appeal to your employer to allow you to plug your Jetta in at the job say mid afternoon or so.

You will need to have another code scan done. A faulty glow plug will certainly show up on a scan, but should NOT bring on the engine MIL light. Erase all faults showing at present. This should extinguish the engine light. Thin start and stop engine a number of times until the light comes back on. This will re boot on-board computer. Do another scan and the fault should show up. If possible do a live reading, paying close attention to the (oxygen sensors) lambda units
Best of luck
John

check wires at glow plug are live when you switch on the ignition.Sounds like you have a glow plug relay faulty switching of to quick.

Yes you have a defective glow plug relay if you have your owners manual you can find it and replace it, the unit also has a timer on it, if you don't have a book look for the glow plugs and follow the wires from the glow plugs to where they terminate there you will find the relay unit and replace it, to test the glow plugs you remove the wires and test each plug by pulling off the wire and with a cheep ohm meter touch one end to the glow plug and one end to ground if it swings almost al the way over it is ok, if it dos not move then that glow plug is bad. if you find 2 or more bad then replace them all, and if a glow plug has shorted and caused this problem you will have to replace the glow plug relay. Good luck.

99 vw passat 1.9tdi was driving sound but just died just turns but wont fire up

are you using cold temperature engine oil!
if not, try changing oil for cold temperature!

hard starting happens due to the cold temperature, air pressure is low during this season so compression inside the engine is low resulting to hard starting!

make sure that all your glow plugs are working.