I have a turbo charged diesel engine no power at take off or at speed in line 5 cyl. merc-benz dodge sprinter van 2.7 l eng.

Question 1

0helpful

1answer

I have a 2015 Mercedes sprinter van diesel 2.1l 4cyl need head torque bolt settings ten bolts

Use new bolts!
Tighten in the following stages 1. 20Nm 2. 100Nm 3. wait 3 mins 4. slacken bolts 1&2 retighten to 20Nm +110 degrees 5. carry out stage 4 for bolts 3,4,5 & 6 then bolts 7,8,9 &10 Sequence, 8 4 1 5 9 7 3 2 6 10 Bolts 9 & 10 are flywheel side of the engine.

Apr 03, 2022 • 2015 Mercedes-Benz Sprinter

2helpful

4answers

Hi on mercedez sprinter van 2008 model 4 cylinder diesel van a fault code is showing -2624-001 -charge air system-offset drift under engine load.this code is not clearing and remains as it is,van has

Clean mass air flow sensor pins, this should fix it.

Dec 15, 2014 • Mercedes-Benz Sprinter Cars & Trucks

0helpful

1answer

Don't know if my question got through last time so

Couldnt tell you without a play under the bonnet ,this is a common rail injection system thats all electronicly controlled so i have no chance ,now if you ask me about a ford D series or a two stroke diesel commer ,even a gardner london bus engine i can help but this fancy encrypted software as used by this age merc? no chance sorry its a merc or a bosch agent only .

Aug 26, 2013 • Mercedes-Benz Sprinter Cars & Trucks

0helpful

2answers

Engine management light flashing and power in limp mode

i am sick off my sprinter shuting down on motarways. What can i do to remove engine management

Jan 23, 2013 • 2010 Mercedes-Benz Sprinter Cargo

0helpful

1answer

What should the charging volts be on my 2007 Dodge Sprinter V6 Diesel when the engine is running?

Do you have any indication that the battery is not being charged properly, such as slow cranking speed when trying to start?
With the engine not running, the battery (fully charged) should show about 12.5 volts with a voltmeter. With the engine running at normal (not idle) speed, the voltage should be 13.5 - 14.5 volts depending on the state of charge of the battery. At idle, the voltage may drop below 13.5 volts depending on how many accessories you have turned on (headlights, a/c, blower motor, radio, etc). If the 12.8 - 12.9 volts you referenced is at idle with accessories on, but increases when you increase engine speed, you're probably OK.

Feb 09, 2018 • 2007 Dodge Sprinter

1helpful

4answers

My 2006 Sprinter has over 30,000 miles and when going up long, steep slopes it slows down, but keeps running smooth. I did change the fuel filter recently and that did help but did not solve the problem. ...

YOU HAVE A AIR LEAK IN THE TURBO SYSTEM CK HOSE'S MY 2006 3500 SPLIT THE HOSE HIGH WHISTLING SOUND. LOW POWER / AND LIMP MODES TOO. ORDER THIS AND BINGO IF FIX IT . YES THE OLD TURBO RESONATOR HAD SPLIT TOO. I did not use the o-ring from the old part I found one 1 side down that fit tight around the new part. A loose o-ring is going to weak air too. Got mine on ebay.

THE SPRINTER TURBO RESONATOR ELIMINATOR
For your late 2004 through early 2007, 2.7 liter 5 cylinder in-line turbo diesel engine, our billet aluminum SRE-06 Turbo Resonator Eliminator completely eliminates turbo resonator failures forever.

The SPRINTER TURBO HOSE ADAPTORS FOR CRACKED HOSES
Completely eliminates turbo hoses cracking and blowing apart at the metal end.

For your 2002 through early 2007, 2.7 liter 5 Cyl. Inline engine, our ADAP-06 billet aluminum fitting with rounded ends, completely eliminates turbo intake hose from cracking and blowing apart at the metal end.

For your late 2007 through present, 3 liter V6 Turbo diesel engine, ADAP-09 billet aluminum fitting with rounded ends, completely eliminates turbo intake hose from cracking and blowing apart at the metal end.

http://www.riordanco.com/our_products_catalog.htm

Oct 27, 2010 • Dodge Sprinter

1helpful

1answer

Torque setting for sprinter cdi 413 cilinder head

turbo diesel ?? sprinter van aluminium head 85/90 lbs ,cast iron head 120lbs

May 28, 2010 • 2007 Mercedes-Benz C230 Sedan

0helpful

2answers

Can u set the injector timing on a sprinter van using a dial gauge in the no 1 injector at the rear of the pump and if so what are the settings please

hi, yes you can,cant remember exact figure think its 0.9mm, use the bolt above where the spline enters the block to adust the timing by ear-give merc a ring for the exact dial gauge setting as it is different for each engine.

Nov 08, 2009 • 1993 Mercedes-Benz Mercedes Benz 300 Class

1helpful

1answer

2004 Dodge Sprinter 2.7L turbo resonator

http://cgi.ebay.com/ebaymotors/DODGE-FREIGHTLINER-SPRINTER-TURBO-RESONATOR-ELIMINATOR_W0QQcmdZViewItemQQitemZ330334225032

Jun 03, 2009 • 2006 Dodge Sprinter

1helpful

4answers

Sprinter van mercedes diesel

if the charge air hose to the intake splits it can cause this condition also.

Sep 17, 2008 • 2004 Dodge Sprinter

Question 2

Anonymous

Expert 55 Answers
Posted on Nov 04, 2009

Anonymous

Expert

Joined: Sep 25, 2009

Answers

55

Questions

0

Helped

50416

Points

142

Before replace your turbo as suggested so called try and error mechanics on your cost, you might want to check your turbo resonator, its common problem with dodge sprinters, in europe no resonator fitted on mercedes sprinters

Anonymous Dec 11, 2010

http://www.riordanco.com/our_products_ca...

Our Products
Our Publications

Welcome to the Riordan Company's
OUR PRODUCTS CATALOG

Q U I C K A C C E S S

PRODUCTS

• Sprinter™ Turbo Resonator Eliminator
• Sprinter™ Cracked Turbo Hose Fix
• Punch 'N Drain™
• The Quik-Kover™
• Building a Replica 1926 Bugatti Model 37A Grand Prix Car from Scratch
• Building an "L-Type" replica model T roadster from scratch
• Converting an Ultralight to ELSA or A/B Experimental

PUBLICATIONS

• Complete Evaluation System
• Path to Profit Poster
• A Systematic Approach to New Product Development
• Technology Evaluation

×

Answer 2

Noe Alamillo

Contributor 7 Answers
Posted on Feb 15, 2015

Noe Alamillo

Contributor

Joined: Nov 28, 2014

Answers

7

Questions

0

Helped

11559

Points

7

Cracked resonator. Replace with aftermarket billet resonator.

Answer 3

Handyman

Expert 125 Answers
Posted on Apr 21, 2015

Handyman

Expert

Joined: Feb 09, 2012

Answers

125

Questions

1

Helped

57685

Points

296

Hi I am a Sprinter Fan, what you have done is not good!. the resonator you replaced with a solid tube,,,, was actually a deresonator which removes vibration and sound therefore way extending the life of a Turbo. Yank that aluminum tube off there and go to a local auto store , they All sell the original equipment for a lifetime guarantee at 35$ out the door and can be replaced in virtually any city anywhere. damn Ebay

Answer 4

Colin Stickland

Dodge Master 22,516 Answers
Posted on Sep 12, 2009

Colin Stickland

Dodge Master

Joined: Nov 04, 2008

Answers

22516

Questions

3

Helped

6992852

Points

66324

These suffer from turbo problems iam afraid ,100.000 miles and then it countdown for a new turbo

Related Topics:

Trustworthy Expert Solutions

I have a turbo charged diesel engine no power at take off or at speed in line 5 cyl. merc-benz dodge sprinter van 2.7 l eng.

4 Answers

Anonymous

Noe Alamillo

Handyman

Colin Stickland

Add Your Answer

Attachments: Added items

Related Questions:

I have a 2015 Mercedes sprinter van diesel 2.1l 4cyl need head torque bolt settings ten bolts

Hi on mercedez sprinter van 2008 model 4 cylinder diesel van a fault code is showing -2624-001 -charge air system-offset drift under engine load.this code is not clearing and remains as it is,van has

Don't know if my question got through last time so

Engine management light flashing and power in limp mode

What should the charging volts be on my 2007 Dodge Sprinter V6 Diesel when the engine is running?

My 2006 Sprinter has over 30,000 miles and when going up long, steep slopes it slows down, but keeps running smooth. I did change the fuel filter recently and that did help but did not solve the problem. ...

Torque setting for sprinter cdi 413 cilinder head

Can u set the injector timing on a sprinter van using a dial gauge in the no 1 injector at the rear of the pump and if so what are the settings please

2004 Dodge Sprinter 2.7L turbo resonator

Sprinter van mercedes diesel

Not finding what you are looking for?

2002 Sprinter

I have a 2015 Mercedes sprinter van diesel 2.1l 4cyl need head torque bolt settings ten bolts

Ask a Question

Check Out the Latest Top Trucks Report!

Top Dodge Experts

ZJ Limited

Ronny Bennett Sr.

Thomas Perkins

Are you a Dodge Expert? Answer questions, earn points and help others

Manuals & User Guides

USA_Vehicle_Fault_Code.pdf....

Related Topics:

Trustworthy Expert Solutions

I have a turbo charged diesel engine no power at take off or at speed in line 5 cyl. merc-benz dodge sprinter van 2.7 l eng.

4 Answers

Anonymous

Noe Alamillo

Handyman

Colin Stickland

Add Your Answer

Attachments: Added items

Related Questions:

I have a 2015 Mercedes sprinter van diesel 2.1l 4cyl need head torque bolt settings ten bolts

Hi on mercedez sprinter van 2008 model 4 cylinder diesel van a fault code is showing -2624-001 -charge air system-offset drift under engine load.this code is not clearing and remains as it is,van has

Don't know if my question got through last time so

Engine management light flashing and power in limp mode

What should the charging volts be on my 2007 Dodge Sprinter V6 Diesel when the engine is running?

My 2006 Sprinter has over 30,000 miles and when going up long, steep slopes it slows down, but keeps running smooth. I did change the fuel filter recently and that did help but did not solve the problem. ...

Torque setting for sprinter cdi 413 cilinder head

Can u set the injector timing on a sprinter van using a dial gauge in the no 1 injector at the rear of the pump and if so what are the settings please

2004 Dodge Sprinter 2.7L turbo resonator

Sprinter van mercedes diesel

Not finding what you are looking for?

2002 Sprinter

I have a 2015 Mercedes sprinter van diesel 2.1l 4cyl need head torque bolt settings ten bolts

Related Topics

Ask a Question

Popular Questions

This 2008 sprinter has two belts, one for the fan

Dodge sprinter serpentine belt diagram

Diagramm serpantine belt 2005 sprinter2500

UNLOCK RADIO CODE DODGE SPRINTER

I HAVE A 2007 DODGE SPRINTER WITH CODE PO299 WHAT

Check Out the Latest Top Trucks Report!

Top Dodge Experts

ZJ Limited

Ronny Bennett Sr.

Thomas Perkins

Are you a Dodge Expert? Answer questions, earn points and help others

Manuals & User Guides

USA_Vehicle_Fault_Code.pdf....