Question about GMC Cars & Trucks

1 Answer

Do i need to flush the AC system out?

I replace a new AC compressor on a 2004 GMC envoy do the AC system need to be flush?

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Master
  • 700 Answers

You do not need to "flush" the AC system, but you will need to put a vacuum pump on it to evacuate all of the air before charging with new refrigerant and the recommended amount of oil charge. It appears that the refrigerant is R-134a and the system takes 48 ounces for a front and rear system or 29 ounces for a front only system. The specified oil is PAG46 and you will need 8.5 ounces for a front and rear system and 7.5 ounces for a front only system. The first link below is the specification page and the second is a video showing how to charge the system. The big parts chain stores will loan or rent the necessary tools and will be happy to sell you the refrigerant and lubricant.

http://www.techchoiceparts.com/refrigerant-and-oil-capacities/gmc-light-truck

https://www.youtube.com/watch?v=im7NZ6JHuwg

Posted on Mar 19, 2019

  • Kardoc Mar 20, 2019

    If you pulled out the orifice tube you would be able to see if the old compressor has come apart and the system needs to be flushed.

×

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE:

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

Ad
  • 91 Answers

SOURCE: 2004 GMC Envoy has trouble idling

Try the fuel filter. Sounds like the engine might be running rough due to weak fuel pressure. Its cheaper to replace, especially if it's still original from 04. Try running some injector cleaner through a couple of tanks of high octane gas.

Posted on Aug 06, 2008

  • 250 Answers

SOURCE: battery removal on a 2004 GMC Envoy

The battery is on the right side behind the fuse box. You need a metric set to undo the 3 screws. Theres one that attaches to the body, one to the bar that goes along the top, and theres one on the left side below the vacuum hose and air induction. After you've taken out those three, you should lift the whole thing out(battery and shroud) together. It's hard to take the shroud off before you lift the battery out. After that, you have to pry the shoud off the battery. The two terminals in the back make it hard. Then just go to any auto parts store and they'll give you a new one. 

Posted on Jan 28, 2009

  • 4 Answers

SOURCE: Removing rear air suspension on GMC Envoy

Just behind right rear tire up in the wheel well. Air inlet is inside right rear quarter near the accessory inflator. Compressor runs 3 lines one for the accessory inflator and one for each air bag.
THere are also 2 sensors, one on each trailing arm that senses load and then raises and lowers accordingly.

Posted on Feb 17, 2010

  • 85 Answers

SOURCE: Where is the cruise control fuse for GMC Envoy

its in the fuse panel under the hood there should be a chart on the cover

Posted on Feb 24, 2010

Rickygittins
  • 715 Answers

SOURCE: I have a 2004 GMC

Hook up a set of A/C gauges and look at this site
http://www.denlorstools.com/autoblog/2009/04/adding-freon-to-car-ac-gauge-readings-explained/

Posted on Aug 04, 2011

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

2004 gmc Envoy HVAC system AC works great for about 20 minutes then just starts blowing hot it's the digital climate control if you let it sit for a while it runs great for 20 min then blows hot again


Rule one thing out.... make sure you're coolant reservoir is full

The compressor has a thermal switch, if it gets too hot in the engine bay, will turn off, then back on when it's cooled off.

Jul 19, 2018 | 2004 GMC Envoy

1 Answer

My 2004 GMC Envoy AC unit is only working for 20 minutes and then it shuts off. I believe its overheating and I don'tknow what to do


may need a recharge or the compressor itself or the clutch unit needs replacin--go to a specialist and havum pressire test system--a partstore like napa can assist you also

Sep 15, 2014 | 2004 GMC Envoy

1 Answer

Turning on the heater or ac causes 2004 gmc envoy


Bad Compressor bogs down engine and stalls

Oct 10, 2013 | Cars & Trucks

1 Answer

2004 GMC Envoy was told compressor is out? Or could it just need to be recharged?


AC service should only be done by a qualified HVAC technician, there are specialized tools and equipment required to diagnose and repair these systems.

Jul 27, 2011 | 2004 GMC Envoy

1 Answer

2004 Mitsubishi Endeavor. I need to replace the AC compressor. a chunk of the housing blew off while driving. I am looking for some information on how to flush the AC system after a compressor failure,...


when you replace new compressor/you shoud have to flush ACsystemby usingR11 AND needto replase expantion valve .after that you need to vaccuming AC system.also put AC compessor oil and refill 134A gas.

Jul 09, 2011 | 2004 Mitsubishi Endeavor

1 Answer

2004 Envoy - Do I need to drain the refrigerant from my A/C system to replace the high pressure transducer or does it have a schrader valve?


Anytime the AC system is opened, it needs to be evacuated and refilled with refrigerant and oil.

Jul 08, 2010 | 2004 GMC Envoy

1 Answer

I took my 2004 gmc envoy xl in to have the a/c filled up...


Your local auto parts store should have the stuff to tests for leaks. They should have a can of ac refill that has a an additive to repair small leaks.

Sep 15, 2009 | GMC Envoy XL Cars & Trucks

1 Answer

A/C compressor is stalling


replace the ac system compressor dryer and orfice tube the ac compressor is locked up

Jul 06, 2009 | 2002 GMC Envoy

1 Answer

No cold air w/air conditioner on for a 2004 GMC Envoy.


Can't go by the pressure. Ck the large lone coming out of firewall, should be col. Small line at ac condensor in front of radiator should be hot.

Static pressure on high side probably 80psI Running 30 on the low side and 1130. will vary depending on oiutside temp Hope this hekoped

May 27, 2009 | 2004 GMC Envoy

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

37 people viewed this question

Ask a Question

Usually answered in minutes!

Top GMC Experts

Marvin
Marvin

Level 3 Expert

84540 Answers

Jonah Oneal

Level 3 Expert

14092 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22484 Answers

Are you a GMC Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...