Pls help me with a timing chain sketch and gears timing for a isuzu kb 300 dtec.....2009 model.

It would be better to have full 'year make model' of the vehicle, but likely one pipe in, one pipe out the the injectors and a bypass pipe back to the tank.

https://www.google.com/search?q=dtec+2009+diesel+filter+housing

..

Code P1520 Isuzu Commanded Versus Actual Throttle ...

AutoCodes https://www.autocodes.com > p1520_isuzu
Code P1520 Isuzu Possible Causes · Faulty Throttle Valve Motor · Throttle Valve Motor harness is open or shorted · Throttle Valve Motor circuit poor electrical ...

N switch position on error p1520 fault code op isuzu kb 300

Fixya https://www.fixya.com > ... > Cars & Trucks > Isuzu
Clearing the codes is simple that is done by removing the fuse of the EFI from junction box 2 for 10 seconds. Make sure to remove the jumper wire and switch the ...

P1520 Isuzu Code Meaning, Causes, Symptoms, & Tech ...

Engine-Codes.com https://www.engine-codes.com > p1520_isuzu
Faulty Throttle Valve Motor · Throttle Valve Motor harness is open or shorted · Throttle Valve Motor circuit poor electrical connection.

What is the solution to the code P1520 Isuzu 4jh1 2006. ...

AutoTrader South Africa https://www.autotrader.co.za > answers > What-is-the-s...
Feb 23, 2020 - According to engine-codes.com, that error points towards an intake manifold runner malfunction on Isuzu engines. In the case of the 3.0 8V ...
1 answer · 0 votes: Hi there According to engine-codes.com, that error points towards an intake manifold runner malfunction on Isuzu engines. In the case of the ...

Thread: 300 tdi engine management light

4x4 Community Forum https://www.4x4community.co.za > ... ·Translate this page Jan 25, 2014 - Exclamation P1520(b) neutral switch error - No power Loss ... I have a 2005/2006 Isuzu KB300 lx d/cab, recently imported from SA to Zimbabwe. I ...

Workshop manual say 0.016 (16 thou).

https://www.manualslib.com/manual/848036/Isuzu-Nhr-4j-Series.html?page=50

0.4 mm (0.016) inches

Video as well.

https://www.google.com/search?q=Isuzu+300+KB+4J%2C+valve+clearance

..

Remove timing cover align all timing marks .may have to remove gears to align by turning untill marks align.

welcome to our USA forum, the country with no KB trucks here.
not a single one, nor a book to match.
zero.
use search, this is asked like 10,000 times here,
and zero to very few answer, if correct at all.
you need a KB book, we do not have one, state side.
google , 4JA1 cam timing, good luck , lots of false hits.
if go to African, Isuzu and buy the book.
be best.

3 posts to a USA forum ,
the country with no KBs
not a one.
my guess you are in AFRICA
and no books, there?
Isuzu shop manuals.
or local forums to find help there?

timing of what, name it?

is this a KB truck, if yes, where?, we dont have them.here.
last USA ISUZU is jan 2009 D-teq right? (not dtec)
is this one? the 3.0L? 2.5? what/?
4JK1 engine? what? or 4JJ1?????????????
is this just a cold start question? or hot engine too.?
Dteq means diesel. can we know size of engine, and country?
so do you have full engine power, even on hills??????
and can you save the stall with fast right foot, easy?
does start easy and run easy hot, or just cold is problem?????
cant guess that, nop...
so what causes stalls.
well over 50 reasons.
idle controls bad, or bad efi sensors or bad engine, 1,2,3.
if cold starts problems check glow plugs.
low engine compression?
what does service mean, name parts changed. filters?
is it turbo diesel?
which engine, we can never guess,?
bad fuel>?
https://en.wikipedia.org/wiki/List_of_Isuzu_engines#Isuzu_J_engine

NO car stated ! , in what country? no model car stated ,just and engine.
is this a diesel?
D-tec 2.5 , or 2.4L ?
is this a Holden engine?
do you mean D-max?
or D-TeQ?
you here>
http://www.gumtree.co.za/s-isuzu+d+tec/v1q0p1


we are usa forum there is no isuzu 2009s here, car or light pickups
get the book from your Isuzu dealer?
or google all day.
how to you know its torque and not angle set.?
only that is in the book, not sold here

badging magic(which one)????????????????
Chevrolet Colorado
Chevrolet D-Max
Chevrolet LUV D-Max
Holden Colorado
Holden Rodeo
Isuzu KB?
Isuzu LB?
Isuzu Rodeo?
Chevrolet T Series
GMC Canyon

a 10 cylinder engine , in what car?
what is KB, the African KB pickup trucks.
or is that OH , Oh, H,,,,,,
we dont have them in USA>
why not get the book at your countries Isuzu dealer.
here our are out of business...

no car stated ;;is this some Africa KB truck??????
no year
fail.... big time.
no country... either.

but can answer in pure mechanics,,
1: get it repaired, (a dah moment?)
2: Inspect that wheel, take it off and inspect all.
brake for damage
wheel bearing.
or axle damage.
all it takes is looking and hands on turning of parts to find
what is binding up.
and is a dangerous car to drive, so dont.

if you dont know how to do inspections.
1: get help
2: or read a book on topic.