Mitsubishi Montero 2002 Ltd Thermostat

It has a filter built into the fuel pump module that is located INSIDE THE TANK. If you had a 2001 Montero Sport Limited, that has a fuel filter at the drivers side ...

Here is a link to the complete torque tables. http://olybrake.com/pdf/fel_pro_torque_specs_guide.pdf

Find the lower hose. Follow it to the engine. Remove the metal housing from the engine that the lower hose is attached to. The thermostat will be behind it.

I’m happy to assist further over the phone at https://www.6ya.com/expert/jeremy_d728a59f986299fa

On a 2002 Mitsubishi Montero LTD, the a/c charging port is between the battery and the windshield. It is the port that has a cap labeled with an "L" (Low Side).

When the a/c is on, "L" (Low Side) gets cold while the "H" (High Side) gets hot.

Make sure you use the Low Side (cold) for adding Freon.

(note: over the counter freon kits should not fit the High Side port anyways)

Please see my tip at http://www.fixya.com/cars/r5929960-s_thermostat . These are generic instructions. If you get stuck or need specific instructions for your car, please get back to me with model, year and engine info.

Make sure there is no air in the cooling system,and that the cooling fan is working,coming on,and going off on it`s own.if it is not ,replace the coolant sensor.

Look right under the evap box,exactly where the ac lines go in the fire wall,it might even have a drip boot on it,it will come out of the fire wall,and turn down,the end will be sort of mashed together to keep out debris.

You should find it by following the top water hose to the water neck.The thermostat should be under it.you have to unbolt the waterneck to get to it

Follow the top radiator hose down to the water outlet. The thermostat is inside the water outlet,Just remove the bolts,replace thermostat,replace gasket,bolt back in place.

Item 21 (the upper interior trim piece) needs to be removed, prior to removing the bottom piece #22. The only screws that hold #21 in are at the handle at the top, then you just pop it out. There are about 6 screws on the bottom part.