Need to replace the constant control relay module

IRCM - integrated relay control module not constant control module. Do you know what a relay is ? Relay for fuel pump , A/C compressor relay , EEC power relay , cooling fan relay's are what is inside the module . What's not working on your vehicle ? Do you know what a wiring diagrams ? How to use a DVOM - digital volt ohm meter ?
Free wiring diagrams here http://www.bbbind.com/free-tsb Enter vehicle info. under system click on engine , then under subsystem click on fuel controls . click search ,then the blue link's one at a time . First diagram you see at the top , IRCM . Ford also used a CCRM - constant control relay module , on your vehicle ford calls it IRCM .

What engine does it have ? 3.8 , 5.0 , or 5.8 l Probably has a CCRM - Constant Control Relay Module The Constant Control Relay Module(CCRM)interfaces with the Powertrain Control Module(PCM)to provide control of the cooling fan, A/C Clutch and fuel pump. The module also includes the electronic engine control(EEC)relay to provide power for the PCM The CCRM is a set of 4 relays in one module

What make , model and year vehicle ? You mean cooling fan's for the radiator . Some makers use a module to control the cooling fans others use relays . Looking at a wiring diagrams would show control componets . Relay contacts could be stuck sending constant B+ voltage , keeping fans on , same with a control module .

other fuses, relays, or ecm faulty.

The Cooling Fan Motor Relay(s) is part of the Constant Control Relay Module (CCRM).
The CCRM is located in the Left Hand front of engine compartment .
(If the relay is bad, the entire module must be replaced.)

Hi!!
Make sure the small hose going from the reservoir to the radiator and the orifice at the reservoir are not clogged. If OK, check electric cooling fan system, specifically the Coolant Temp. sensor, Fan Relays and Constant Control Relay Module (CCRM).
Electric cooling fan system consists of a fan and electric motor attached to the fan shroud.

• Engine temperature is monitored by the Engine Coolant Temperature (ECT) sensor.
• Fan is controlled by Constant Control Relay Module (CCRM) with inputs from Powertrain Control Module (PCM).

The electric cooling fan is wired to operate only when ignition switch is in ON position and engine temperature exceeds specified temperature, or when A/C is on and vehicle speed is less than 45 MPH. During hard acceleration, the Wide Open Throttle A/C Cut-Off (WAC) relay controls the A/C clutch and cooling fan. A signal is sent to PCM and then to the CCRM, where the module de-energizes the A/C clutch and cooling fan, decreasing engine load during acceleration.
Good Luck!! A HELPFUL - 4 THUMBS - rating for this solution would be greatly appreciated. Thank you for using FixYa!!

All the relays are together in a module,call IRCM module,it is located under the long plastic cover on the top of the radiator. I think the engineering number on it is 12B577 ? if there's a problem with one of the relays,it is serviced as a unit.Check all the grounds at the battery too. A common problem with taurus was corrodid cables,

is the same relay that works with the fuel pump it's call constant control relay module

You need to replace this part!

its not an actual relay is like a relay assembly

Constant Control Relay Module (CCRM)


The Constant Control Relay Module is located at the LH front of the engine.