EGR VALVE 1997 CHEVY MALIBU 3.1 V6 LOCATION - 2005 Dodge Caravan

codes p 0404 refers to exhaust gas recirculation (EGR) system---range /performance====causes hose leaking/blockage---wiring---EGR valve /solenoid
code p 0405 refers to EGR valve position sensor A---low input===causes ---wiring short to ground --EGR valve position sensor ---ECM
replace the egr system is a good option

Fuse Box Diagram Chevrolet Malibu (1997-2003)

https://fuse-box.info > chevrolet > chevrolet-malibu-19...
It is located on the driver's side of the instrument panel, behind the cover. The location of the fuses in the passenger compartment: Chevrolet Malibu (1997, ...

Hi Jim, The Exhaust Gas Recycle valve is usually mounted on a tappet cover and is connected to the the intake manifold. It has the function of recycling the fumes from the sump and burning them in the combustion chamber. Regards John

I got a 2001 chevy malibu v6 3100 sfi.I just got this car Wednesday one of the coil packs are in the rong spot they got it 3 6 5 2 4 1 should be I think 5 2 6 3 4 1 and they have it wired 1 5 3 6 4 2 what is the order it goes 1 4 6 3 2 5 can someone please help me

it is often a mix of fuel/oil vapor and water, use carb cleaner to remove it every so often and re-install it after it is dry.

Symptoms of a bad EGR valve are usually stumbling idle or the engine stalling when the car is warm (normal operating temperature). Find the EGR valve and locate the vacuum line attached to it. Start the engine cold and wait for it to warm up. When the engine starts to stumble, pull off the vacuum line. If the EGR is bad, the engine idle will stabilize and no longer stumble.

The EVAP service port is located in the EVAP purge pipe between the EVAP purge solenoid and the EVAP canister. The service port is identified by a green colored cap.



Fig. Showing location of (1) Evaporative Emissions (EVAP) Canister Purge Solenoid and (2) Exhaust Gas Recirculation (EGR) Valve




Fig. EVAP Purge valve solenoid (3) mounting bolt (2) and insulator (1) on 2000-2005 4.8L, 5.3L, 6.0L Engines

Hope this help (remember rated the post).

underneath car driver side

If it's a US car then there is not an egr on the 2.2L engine. I think some of the mexican and oversea's engines had them, but not here in the US.

bleed the abs unit first then bleed all the brakes