2000 Suzuki Aerio - Answered Questions & Fixed issues

oops didnt read how to tow that suzuki,oops. how far you go , over 200 miles>? is it an auto or stick? flat towed?? dolly towed,? towed from front or rear.? we cant guess any of that and are all covered in the operators guide. clear as a bell too. towing cars , most will damage the rear transmission bearing. because its dry when engine not running. so the rules are very strict. due to that hard fact. soon as you tow anything , thing, "rear bearings." or if Fwd car, same on front. most cars are not designed to be towed and some only short distances.

7k clearances are ( HOT ) Inlet 0.008 in ( 0.20 mm )
Exhaust 0.012 in ( 0.30mm)

You have probably burnt out the clutch pack by turning trans from the wheels. Get the car looked at by a transmission specialist.

You don't have to have them but it keeps the old fluid and debris from getting pushed back up the lines and into the mastercylinder thus possibley having a small peice of debris get caught in a valve in the mastercylinder then it won't work right.

sound like ur turning steering hareness is shorting out

The only thing that would give you more power without hurting fuel mileage would be a turbo charger. Any other method would decreas mileage.

I found the solution for my problem

Thanks

1. 123457

let them fix it. we can't see what is going on, blind. not told does the starter motor crank fast or not? or cranks fast but will start the engine. seemss battery lugs or battery is bad, my wild guess. blind my guess is starter is dead. is this UK or India or Australia,.??? no engine told. let them fix it, .and pay them. the shop.

Torque specs komatsu Cummins S6D102E-1 engine

There could be a vacuum leak causing this. Check all hoses that they are all connected and not all cracked up. it could be an intake manifold leak you need to check with a little water along the intake manifold to see if it gets sucked in. Some mechanics check by spraying starter fluid around the engine to see if it speeds up from an idle, but that can be dangerous if you have an open spark.

Tried looking up on kbb and edmunds.com and found nothing, sorry.

I think I would have it replaced.

welcome to USA forum the country with no F6 cars like that here in fact are illegall to import. (thus no books /parts here) ask on a Philippines forum>? Gas engine, generic answers.... stalls have over 50 causes. its a fact and no person in internet bunny land can guess, yours ever. unless like Luck of the Irish ,etc.? why ask at all.? here. or ask how to DO tests, or get a mech there to fix it (sure) stalls, in pure physics in a more simple list. 1: lost of 12vdc to the EFI systems controllers, power loss. DC. 2: Bad spark. try new spark plugs yet, called a tune up? 3: bad fueling , it can stop fueling or go too rich called flooding 4: bad engine, yes,engines can fail hot, (head valve stuck open) or engine cant pump air, filters? or major engine problems. there are test for each class failure. the other 3 cause are here. too. EGR stuck open if fitted, will cause a stall but not driving hard and fast. CAT melted, blocks exhaust(if fitted) and makes the engine useless as per #4 above. loss of air. yes. if the engine, keeps going at stall by the driver pressing throttle more (this is more air) and engine recovers then it's a loss of air, in some cases, or EGR stuck. IF THIS CAN'T PREVENT THE STALL, SAY SO,. using the right foot actions there are like 1 to 10 test in a shop to find this. if can be demonstrated to them., let them?>

what's wrong with English , you can see its an english site AERIO 2008 which engine? the thermostat is on the end of the long large radiator hose. the one that gets hot first is that hose. it goes to the thermostat housing that you must remove. if car is USA car. then our book for 4 bucks answers this but is in ENGLISH. offical USA, Suzuki books, not clones or worse . https://suzukipitstopplus.com/Products/1010-2007-aerio-service-manual.aspx

Not likely. A bad coil pack or fouled spark plug will. If the injector is not metering enough fuel, the cylinder will experience a lean misfire.

https://suzukipitstopplus.com/Category/3-suzuki-service-manuals.aspx my guess, Fault p0481 cooling curcuit fan 2.

pull the cluster from dash and install lamps check the fuse 1st

If you do not keep anything of value on your bot account it will no longer be worth hacking. So if you quit mining and farming there will be no reason to hack you.

You can download the manual from Suzuki for $3.95 at: http://suzukipitstopplus.com/Products/1002-2003-aerio-owners-manual.aspx