Top 20 1991 Volkswagen Golf Questions & Answers

Blocked injector jets or fuel line, could be restricted by sediment from fuel tank (this often happens when you let fuel run low, it sucks up minute dirt settled on tank floor)....check oil for white gunk around inside of cap (water in oil) ..... make sure all HT leads are good and earth connections sound... Red.

lower left near above the hood release. Some of those Golfs had a "knee bar" that makes the fuse panel a little harder to see or reach under the dashboard.

This engine is fully electronically controlled, you must do a fault code test, once you have the fault codes you do the required fault codes testing per the factory service manual and replace or repair the problem(s) that caused the loss of spark.

Hi. This simpley screws off the back of the dash cluster and reove the bolt holding it into the gearbox. remember to fit the grommet properly otherwise water will get into the car

better get a new battery soon. You are close to being stranded. Dim lights also indicate the alternator is getting tired. A new battery might fix alternator output but if batter isn't getting recharged, replace alternator too.

is this ford? replace starter solonoid

I am sorry our diagrams don't go back this far.

Air filter

Hello and welcome to FixYa!
Regarding the coolant loss, I suspect that the coolant in the reservoir is above maximum. If it's above the maximum level the coolant will overflow, so it must be on the max level or a little lower.
Regarding the sludge on the oil cap and wet spark plug, it's not normal. The valve seals of the engine can be worn out that's why there's oil marks. If that's the case the valve seals must be replaced to resolve the issue.
Please do try cleaning the oil cap as well and observe if it will build up sludge again. It can be just dirt underneath the oil cap.
Hope this helps and thank you for using FixYa! Have a good one!

Can get from:https://erwin.volkswagen.de/erwin/showHome.do;jsessionid=37497CA58CBEB41E77FB60247660EF69.ASTPVWE1

maybe your engine revs alittle low on tick over

hi geoff,the best way to sort out this problem is to get a diagnostic done at a dealer on the computer.ask for a detailed (no codes) answer and then you can do the work yourself,if you are competent.cost £45 at most main dealers but skoda and seat are cheaper.....
regards,geoff.h

replace your thermostat

this year has a distributor ,so just use a timing light ,or start engine and turn dist till it speeds up then back it a little and should be about right if it pinks then back it off a little more

What are the condition of the wheel cylinders / calipers?

Hi, Lee,
you have lose earth connection somewhere.It is difficult to find.Can be anywhere.

do wot i do, before taking of draw the route of the serpentine belt.

$54.95
This one is for a 2.0L 4cyl 8V application found at most popular VW internet stores. Very simple to install although requiring some mechanical ability to tackle this work.

Forget.Completely not the same.Golf 4 dashboard have lots of electronics.ECM controled.

catalystic converter