20 Most Recent 2004 Chevrolet Suburban Questions & Answers


If the battery isn`t the problem, make sure that the drive belts ate properly tightened.

If they are, check and clean the cables and terminals that connect to the battery. When looking at the cables, look GOOD. The cable may be corroded inside the insulation.

Also check the engine ground and make sure the alternator is also well grounded. Be sure to check the red output wire is not shorting.

Be sure that the red positive cable is not shorting. You may aven we interested in removing the alternator and having it checked for internal problems.

2004 Chevrolet... | Answered on Jul 28, 2018


if your brake fluid in the master cylinder is low it will also cause it to light up

If you need further help, I’m available over the phone at https://www.6ya.com/expert/david_4c166ba81493f541

2004 Chevrolet... | Answered on Feb 22, 2018


fuel pump or dirty gas filter. check gas filter.

2004 Chevrolet... | Answered on Feb 02, 2018


if there are cat converters on it they are probably plugged.
not sure y pipe will do it. unless he punches out the cats while putting in a y pipe.

2004 Chevrolet... | Answered on Jan 23, 2018


Wheel bearing can be a big job without the correct tools. Better to pay a good mechanic.
Assuming your Burb is a 4X4, My first suggestion is get ALL of your wheels and tyres checked. Make sure they are inflated to the correct pressure, the tyres aren't damaged or badly worn and they are all balanced.
Next, jack up the car and REST IT ON AXLE STANDS. Your going to be shaking the car around!
DON'T JUST USE A JACK!!! It will fall off!
Once the wheels are off the ground, Spin the wheel by hand with a bit of force and listen to the wheel. A bad bearing will produce a 'gritty' sound. A brake disc noise will have more of a 'ring' to it.
Grab the wheel top and bottom, and push and pull in a rocking action. Do the same at the left and right positions. If you feel movement or here a 'clonk' noise get the whole suspension checked by a good mechanic. The above test shows if there's any play in the ball joints as well.
I would also suggest you get the drive shaft CV joints checked. Worn ones make noise when cornering.

2004 Chevrolet... | Answered on Jan 13, 2018


Many possible causes - have you looked for trouble codes (DTCs) with a code reader?

2004 Chevrolet... | Answered on Jan 04, 2018


The other should be on the right side with door open .

2004 Chevrolet... | Answered on Nov 24, 2017


Get the codes pulled. That will tell you what is wrong.

2004 Chevrolet... | Answered on Oct 19, 2017


Is the check engine light on? Are there any codes?

2004 Chevrolet... | Answered on Sep 29, 2017


Check the grounding wires behind the front left tire. GM put the wiring directly behind the tire and there is a grounding bolt in the body. This usually gets corroded and nothing in the 4x4 system will work. Clean this up and apply some RTV Gasket sealer to help weather - proof it.

2004 Chevrolet... | Answered on Sep 27, 2017


check for problem circuit and 4wd actuator

2004 Chevrolet... | Answered on Sep 10, 2017


Automatic climate control or manual ? blower motor control processor , probably . or the blower motor , or the HVAC control module etc.... All these are just guesses , without testing the electrical circuits . Did you check the BLOWER fuse 40amp located in the under hood fuse / relay box And the HVAC /ECAS fuse 10amp in the under hood fuse box ? Plus HVAC I fuse 10amp located in the I/P fuse box .

2004 Chevrolet... | Answered on May 07, 2017


These problems are usually caused by a faulty blend door actuator which controls the position of the air mixing door, and in vehicles with more than one air zone (passenger/driver, front/rear, etc.) there will be a door/actuator for each. These electric blend door actuators are self-calibrating - there is a feedback circuit (wiper type potentiometer) that tells your HVAC control the position of the door. It is not unusual for this potentiometer to wear causing loss of signal at various positions, which then will cause erratic movements of the door (if the circuit fails to open circuit or shorting, the door will default to fully open or closed - i.e. hot or cold air only).

2004 Chevrolet... | Answered on Mar 29, 2017

Not finding what you are looking for?
2004 Chevrolet Suburban Logo

946 questions posted

Ask a Question

Usually answered in minutes!

Top Chevrolet Experts

Marvin
Marvin

Level 3 Expert

85206 Answers

Jonah Oneal

Level 3 Expert

14092 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22484 Answers

Are you a Chevrolet Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

Suburban Chevrolet

  • Suburban Chevrolet

Most Popular Question

many hours takes replace heater coil in

  • Cars & Trucks
Loading...