20 Most Recent 2002 Chevrolet S-10 Questions & Answers


I would think it was part of the body control module.

2002 Chevrolet... | Answered on Mar 06, 2019


Install a fuel pressure gauge. Key on engine off it should build close to 60psi and back off a few lbs. It should hold steady and not drop off. If it does drop off, replace the pump. Engine running at idle, it should be reading right around 52-54 psi. The engine will barely start/run at 50 psi.

2002 Chevrolet... | Answered on Sep 30, 2018


i have been having to remove the hot post from the battery when its not being drove, if not my battery dies, I was told that this is a ground somewhere. ??????? Who told you that ? You have a parasitic drain on the electrical system . Something is staying on or there is a short , maybe one of the computers on the vehicle isn't powering down . GM trucks have instrument cluster problems that can cause this . Can also bring down the class 2 serial data network causing the vehicle not to start . Do you know what class 2 is ? All the computers ,control modules ,what ever you know them by , all share info. send commands etc. on the network .
The BEST Way TO Perform Parasitic Draw Test
Buick Class 2 Operation Diagnosis 1998
012 GM Class II Communications
Your best bet mite be to take it to a qualified repair shop.
Chevrolet Truck Battery Dies Overnight Part



2002 Chevrolet... | Answered on Dec 30, 2017


Not the neutral safety switch. That piece you see on the dash, the PRNDL, has a needle that's controlled by a wire connected to it and on the column collar that's part of the shift lever. Assuming you've a column shift. When the little clip on the wire that holds these, the collar and the needle, comes off, that is what you have to get to, in order to push the little clip on the end of the wire back on the collar. It's directly under the PRNDL but more close to the L.

2002 Chevrolet... | Answered on Dec 07, 2017


first up jack up the vehicle and remove the damaged wheel
fit the spare tire and then place an indicator ( rod on a brick ) close to the rim of the spare and turn the wheel
if the axle of hub is bent you will see the rim get closer then further away from the indicator as you turn the wheel
if it is , replace the axle and bearings
if not there will be no axle damage but the bearing could be "brinnelled "( a bearing term where the balls or rollers have been imprinted into the race from impact) in which bearing failure will become evident in 10-20,000 miles
next step is to go and get a rear end wheel alignment done as there could be suspension damage that will cause handling and tire wear problems

2002 Chevrolet... | Answered on Jul 16, 2017


Yours looks just like the one I had to replace recently on my 2000 camaro, but mine was on top of the tank. Yours looks much easier to replace. See link below. Fix Your Chevy With Your Own Hand

2002 Chevrolet... | Answered on Jul 03, 2017


Test with a DVOM - digital volt ohm meter , find a power distribution diagram an check the flow of Voltage . Do you know how to do basic automotive electrical testing , how to use a DVOM , how to read a wiring diagram ? Electric Testing Techniques You Need to Know

Copy of Voltage Drop Essentials TST Motor Age

Basic Electricity for Service Techs Ohm law Current Flow Opens Shorts

You can find free wiring diagrams here http://www.bbbind.com/free_tsb.html

Starter Voltage Drop

There is no guessing in automotive electrical system repair !

Check main B+ cable to the starter .



2002 Chevrolet... | Answered on Mar 18, 2017


In general you have to drain the rear end, remove the cover, remove the carrier pin, remove the axles, then remove the carrier from the main shaft and replace the bearings.

2002 Chevrolet... | Answered on Feb 24, 2017


The gauge is bad or sending unit in the fuel tank ! There are videos on youtube showing how to test the electrical circuit . Fuel Gauge Troubleshooting

2002 Chevrolet... | Answered on Nov 12, 2016


might need a special O2 sensor socket to remove, depending on how tight it is. Sometimes you can access it with a wrench

2002 Chevrolet... | Answered on Nov 10, 2016


Are your fans working

2002 Chevrolet... | Answered on Oct 12, 2016


Radio 12v  orange  +  radio harness Radio Ground  black  -  radio harness Radio Ignition  dk. green  +  radio harness Radio Illumination  brown  +  radio harness Factory Amp Turn-on  orange  +  radio harness Notes: The amplifier is behind the glove box. Power Antenna  N/A     LF Speaker +/-  tan - gray  +,-  radio harness RF Speaker +/-  lt. green - dk. green  +,-  radio harness LR Speaker +/-  brown - yellow  +,-  radio harness RR Speaker +/-  dk. blue - lt. blue  +,-  radio harness

2002 Chevrolet... | Answered on May 19, 2016


Fritz, Clear codes, Plugs and coils try switching them around, not using the same cylinder, to see if code changes to different cylinder. this would help diagnose bad coil or plug. See links below for full instruction. I have had this code come up because of a bad/dirty fuel injector also. Last link tells what other reasons code could be thrown.
"I hope this helped you out, if so let me know by pressing the helpful button. Check out some of my other posts if you need more tips and info."
Chevy Trailblazer misfire DIY diagnosis step one p0301 p0302 p0303 p0304...

Trailblazer P0301 Is the coil bad

P0302 OBD II Trouble Code

2002 Chevrolet... | Answered on May 13, 2016


Is this a 4x4? If so, vacuum switch on top of the transfer case and any HVAC parts that are damaged. That might be the part they replaced for you. Is there a hiss coming from the dash controls? If so, you will need to replace the mode switch with one from a junkyard. Otherwise you have to buy the whole control unit. I think it's about $65 bucks from Amazon. Probably $165 from the dealer. Here is some info on an older truck in the link. GMC Sonoma Chevy 10 Transfer Case Vacuum Switch

2002 Chevrolet... | Answered on Jan 18, 2016


check it out first, I had a car that had a piece of plastic (grocery bag)
causing the noise. otherwise sounds like motor is going

2002 Chevrolet... | Answered on Jan 18, 2016


The Internet, though, has a large number of web sites where you can buy service manuals and schematics from bookstores, publishers, and other collectors. Here is just a sampling of what sites are out there:

Chilton Repair Manuals
http://www.chilton.cengage.com/

Haynes Publishing
Haynes auto manuals
http://www.haynes.com/

Factory Service Auto Manuals
http://www.factoryautomanuals.com/

Vintage Books
Vintage books com Rare used and out of print books
http://www.vintage-books.com/

AutoLit
http://www.autolit.com/home.htm

2002 Chevrolet... | Answered on Jan 18, 2016


If the fuel pump is working and it won't crank, then it could be your starter. The easiest way to test that yourself is to use jumper cables hooked directly to starter. Yes that can be dangerous if done wrong. If you do, here's some pointers.
1 - Make sure the vehicle is firmly parked, E brake, neutral, wheel blocks, anything to make sure it won't move.
2 - A standard that's in gear will move when the starter turns
3 - The last time I did this I had the drive wheels off the ground, no chance of moving.
4 - hook up the cables to the terminals on the starter first, making sure the cables are not in the way of belts / fans etc. Then connect them to the battery, only briefly, if it cranks, the problem is with a fuse / wire / computer etc. If it doesn't crank, buy a new starter. Hope I helped, Grim

2002 Chevrolet... | Answered on Nov 05, 2015


Check to see if your heating system is properly filled. Air in system can often prevent the proper flow of hot coolant into the radiator core resulting in your issue.

2002 Chevrolet... | Answered on Oct 20, 2015


access door under car on bottom follow oil cooler lines from radiator.

2002 Chevrolet... | Answered on May 30, 2015

Not finding what you are looking for?
2002 Chevrolet S-10 Logo

679 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

Top Chevrolet Experts

Marvin
Marvin

Level 3 Expert

85206 Answers

Jonah Oneal

Level 3 Expert

14092 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22484 Answers

Are you a Chevrolet Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

S 10 Chevrolet

  • S 10 Chevrolet

Most Popular Question

tryed start 2002 s 10 4 3 clicked one

  • Cars & Trucks
Loading...