Https://www.polarisatvforums.com/threads/2006-polaris-sportsman-500-efi-not-getting-power-to-the-fuel-pump.191336/
This thread should help you.
SOURCE: Fuel pump problems
http://www.motosport.com/utility/oem-parts/POLARIS/2000/SPORTSMAN-500-_-A00CH50AL/FUEL-PUMP-_-A00CH50EB
There is an assembly diagram on the link
Go to Dealer & Buy a Service Manual
Try You Tube Video also
Carburetor could be dirty or fuel filter clogged. Put a container of carburetor cleaner in your gas tank, fill it up, and run at idle for 5 minutes, see if that helps clear up the problem. Carburetor float could be stuck, or choke plate.
Need to check if distributor coil is active.
SOURCE: What causes my 2008 polaris rzr 800 efi to back fire when I release the throttle
First thing first chang the plugs that model you have is bad about fauling plugs do to not allowing motor to warm up even if you were moving it five feet from were it was setting and don't matter if you just replace them early in the year, if it is cold this will happen with out ? So do this first.if that don't fix the problem Ok on your intake tube between the air box and the throttle body should be a small sensor mass air it has a small screw that holds the adjustment for it loosen the screw and and turn it counter clock wise just slightly tighten back and start bump throttle keep repeating the process untell you have a quick throttle response . Be sure to shut off and restart each time you move it keep your eye on the check engine light when you have it right the lite will stay out .good luck
556 views
Usually answered in minutes!
×