Suzuki 2005 KingQuad 700 4X4 - Answered Questions & Fixed issues

if the relay is clicking it sounds like a bad battery or starter

Question edited to add maker. Question moved to the correct category 'make model'. Remove the throttle body and clean it thoroughly. It is staying open. https://www.google.com/search?q=Suzuki+KingQuad+500+that+surges+at+idle ..

Sounds like the carb need a professional cleaning.. i said PROFESSIONAL cleaning..

Still sounds like the pilot system in the carb is not clean... these are TINY passages.. several of them too! .. some hidden by blind plugs that have to be removed to properly clean the carb!!! If you are not sure how to do this.. take it to a professional!!!!

depends on what year and model, it would be about 50hp or 36kw that would be max rated, it will drop from there depending on age, mechanial condition, temperature, altitude, grade of petrol etc

you have a pinched wire someplace in your wire harness. maybe a melted spot also could cause this.hot wire shorting out to ground on frame. anything you had loose lately. under gas tank , wires got against exhaust pipe, wires rubbed bare from wear ? broken wire in harness could cause it.

No they are air cooled

fuel system dirty someplace. carb ,filter in tank, inline filter or air filter dirty. clean or replace as needed.

Well its a pump their isn't really a vacuum their is pressure do to v.o.c's but not enough to push fuel to the engine it needs to be pumped out at about 60 p.s.i

one of your repaired wires is not getting power or ground.. Recheck your wires,. And most likely look farther up the wire loom for burned threw wires..

check an oem parts supplier like cheap cycle parts dot com

I'd guess bad wiring from the regulator. mine regulator burned up and I had to run a new wire from it to the battery.

Suzuki atv manuals Suzuki Motorcycle Manuals Repair Manuals Online

Ok... Follow these links: Suzuki atv manuals BEST BRANDS REPAIR MANUALS

DO NOT JUMP WITH A CAR BATTERY.. the amperage is TOO high for a quad electrical system!!

hi try on this forum www Quad Forum co uk Index page

Have you checked to see if the spark plug is firing?? How do you know the "injector" is good? Is the spark plug wet after you try to start it for a few minutes?? More info please...

does it happens right after u start it ? is it cold of hot ?

More than likely the stator coil or the igniter module is defective.

check suzukiatvforums . com