RTO 125cc ATV Quads Full Size Adult four Wheelers - Answered Questions & Fixed issues

I would not think so check for broken wiring, kill switch and dirty terminals and connections

when engines not running turn the gas off . And it sounds like you need to adjust your throttle pin that goes into the carb take the clip off the pin and move it down one good luck

Probably a bad CDI check to see if it has spark if the CD I is bad count the prongs on on the plug go on ebay they are around 20 bucks depending on how many prongs are on the plug If you need further help, I’m available over the phone at https://www.6ya.com/expert/brandon_79b580f5a99c4386

needs a new spark plug or coil, coil wire and cap.

check your ground! First. :-)

If the oil is milky it has a bad and leaking seal somewhere that the gas is gitting in, or it has water in it. Water does not mix well with oil as you may know so I'd guess its gas is getting in. If it does run, change the oil right away then see if the oil develops the milky look again. Probably a seal would be my guess. Good luck.

Could be the shift shaft assembly... needs professionl attention

I am not sure what you mean to "Reset" the carb is it leaking? or flooding the engine out? need more info before I go into explaining how to rebuild the carb

Go up 2 sizes on the pilot jet that's the little jet next to the main but before you change sizes make sure that it's not plugged up hope this helps you If you need further help, I’m available over the phone at https://www.6ya.com/expert/brandon_79b580f5a99c4386

You seem to have many problems with this ATV reading the different postings have you checked the compression on all 4 cylinders if so what were the readings ?

does it have gas is the fuel turned on does it have spark is the battery good does it crank you have to try a little harder to get proper help !!!

blocked fuel line, blocked fuel filter, petcock is closed.

take off the horn unit power it direct if it works its ok, if not replace, next step wire a small bulb into the horn wires and press the button if it lights the switch is ok, if you have a circuit tester put one end on the battery ground and check for power in the horn wires if their is power there put the lead on battery positive and press the horn button if there is no power their the switch or wiring is faulty

Question edited for clarity, correct order and add maker. Question moved from Cars and Trucks to model category. Service manual https://www.manualslib.com/products/Suzuki-Kingquad-5901790.html ..

https://www.motosport.com/atv/oem-parts/suzuki/2004/eiger-400-4x4-auto/wiring-harness

https://www.polarisatvforums.com/threads/2006-polaris-sportsman-500-efi-not-getting-power-to-the-fuel-pump.191336/ This thread should help you.

Question edited for clarity.

SHI0206 - Kawasaki & Polaris Diesel UTV Starter

MFG Supply https://www.mfgsupply.com > shi0206 OEM Replacement This part is aftermarket equipment designed to replace the original manufacturer's part numbers specified here. ... 2014 Polaris Ranger Diesel. US$162.33

Ranger ETX Starter Replacement *UPDATE

Polaris Ranger Forum https://www.rangerforums.net > ... > General Discussion Sep 20, 2018 - Replacement: Carefully line up and press into place the new starter. Take top bolt and begin threading into hole but do not tighten. This will ... Starter Replacement - Polaris Ranger Forum Apr 29, 2018 Diesel ranger issues - Polaris Ranger Forum Nov 25, 2014 Starter Problems ' Polaris Ranger Forum Mar 16, 2023 Starter solenoid - Polaris Ranger Forum Jul 7, 2021 More results from www.rangerforums.net ..

It sounds like the battery is worn out. It is lacking Amps and Volts. Or the battery contacts are dirty or corroded causing a bad contact.

Question edited for clarity. Lots of help in the links, plus here is your service manual

2009 Polaris Outlaw 450 525 Service Manual.pdf

No-IP https://quads.ddns.net > service-manuals > 2009 P... PDF Refer to the "KTM Engine / Carburetion" section in the back of this service manual for carburetion maintenance details. Normal wear from engine vibrations ...

OUTLAW 525 IRS

Polaris https://cdn.polarisindustries.com > parts-manuals PDF Follow the recommended maintenance program outlined in your owner's manual. This program is designed to ensure that all critical components on your vehicle are. 210 pages https://www.google.com/search?q=2007+Polaris+Outlaw+525.+Where+is+the+fuse+location

Here you go - this covers the 50/90 2001 & 2002 - Good Luck. I know people roll their eyes when they hear it - but I've seen it more than once...check every connection. Grounds. Everything. One loose ground will mess up a lot of time. All The Best, Justin McCartney