kawasaki ATVs - Popular Questions, Answers, Tips & Manuals


Did you drain the carburetor at the end of the season, or shut off the gas valve and run the carburetor dry? If not, the issue is probably varnish and gum from the evaporated gas plugging up the carburetor. You will have to pull the carb apart and clean it.

kawasaki 2005... | 27 views | 0 helpful votes


no adj .. belt drive i think.... replace belt only fix.

kawasaki 2004... | 36 views | 0 helpful votes


not familiar to your set up but as with any system encluding motor cycle. Get a hose and syphone all that you can out and fill with the proper gas. Start it up...it might be a little harder to start but once you get it started it will clear. I once had a guy fill my car with diesel...supposedly gas and I drove the car a long way then kept stopping up with gas. worked fine....sure did clean the engine.

kawasaki 2012... | 34 views | 1 helpful votes


Hi
We have solution for your kawasaki mule 4010 . if you want workshop manual so please contact us : heavymanual1994@gmail.com


Thank you

kawasaki 2012... | 34 views | 0 helpful votes


what year ? 1999 should be 15 to 20 mm intake on exh 18 to 23 mm i think depending on year. they run tight. adj at tdc on comp stroke with valves open far as they can. have to rotate eng for each valve to open fully and independently one opens and other closes at same time. should be very quiet if adj correctly.adj the closed valve only when fully closed

kawasaki 2005... | 70 views | 0 helpful votes


that's about 50mph,how fast did you want it to go?i would ask dealer what the top speed should be,and think about warranty service.

kawasaki 2013... | 104 views | 0 helpful votes


this video's may help you with you're problem. \/
Also for pulling the bearing out of the axle I recommend a bearing puller set you can buy cheep online and rent a slide hammer from most auto shop's another video about the tool. \/
and use a socket that has the same outer diameter as the bearing to install.
If the rear axle is not the same please disregard this
but the video may still give you some insight as of whats ahead.

kawasaki 2004... | 72 views | 0 helpful votes


i would return the mule to the dealer where you bought it,and let the warranty pay for the battery and testing,etc.

kawasaki 2012... | 73 views | 1 helpful votes


fuse block ? under dash, hood or seat. trace your wires to the fuses easy peasy

kawasaki 2012... | 129 views | 0 helpful votes


It sounds like it needs to be adjusted or something in the transmission stripped, have you checked the rear axle and bearings, if that is the issue i think yo can get a axle and bearings for$250-$275

kawasaki 2005... | 58 views | 1 helpful votes


Will it start with starting fluid

kawasaki 2012... | 51 views | 0 helpful votes


is the ignition switch bad? if it has been working fine off of the 2 wire switch,thats what i would replace with.if it worked with 2 wire switch why would you need 4 wire switch.

kawasaki 2004... | 47 views | 0 helpful votes


Check for a fuel obstruction, sounds like urs starving for fuel, test or check your lines, fuel pump, any valves, etc are free and clear. I hope this helps!

kawasaki 2005... | 53 views | 0 helpful votes


Sounds like not getting petrol, clean petrol tap to get a good flow and clean and strip carburetor the needle and seat could be clogged any way clean and blow out jets and holes with compressed air put back together and away you go.

kawasaki 2005... | 131 views | 1 helpful votes


I suggest you check the exhaust isn't partially blocked and then if OK ensure the cam timing, valve clearances, etc. is correct.

kawasaki 2005... | 110 views | 0 helpful votes


Order the service manual directly from the manufacturer/distributor.

kawasaki 2005... | 34 views | 0 helpful votes


Open fill cap and oil level should be full.

kawasaki 2012... | 38 views | 0 helpful votes

Not finding what you are looking for?
kawasaki Logo

531 questions posted

Ask a Question

Usually answered in minutes!

Top kawasaki ATVs Experts

Jason

Level 2 Expert

218 Answers

Marvin
Marvin

Level 3 Expert

84540 Answers

Lawrence Oravetz

Level 3 Expert

10528 Answers

Are you a kawasaki ATV Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...